REMA TIP TOP/NORTH AMERICA INC -- COLD VULCANIZING FLUID, 207 -- 6850-00N077048 
=====================  Product Identification  =====================

Product ID:COLD VULCANIZING FLUID, 207
MSDS Date:06/14/1993
FSC:6850
NIIN:00N077048
=== Responsible Party ===
Company Name:REMA TIP TOP/NORTH AMERICA INC
Address:200 PARIS
City:NORTHVALE
State:NJ
ZIP:07647-2205
Country:US
Info Phone Num:201-768-8100
Emergency Phone Num:800-424-9300 (CHEMTREC)
CAGE:GO624
=== Contractor Identification ===
Company Name:REMA TIP TOP/NORTH AMERICA INC
Address:200 PARIS AVE
City:NORTHVALE
State:NJ
ZIP:07647-5000
Country:US
Phone:800-334-7362/800-225-7362
CAGE:GO624
Company Name:REMACO INC REMATIP TOP/NORTH AMERICA INC
Address:200 PARIS AVE
Box:City:NORTHVALE
State:NJ
ZIP:07647-2205
Country:US
Phone:201-768-8100/800-424-9300(CHEMTREC)
CAGE:03795

=============  Composition/Information on Ingredients  =============

Ingred Name:ETHYLENE, TRICHLORO-; (TRICHLOROETHYLENE) (SARA 313)
    (CERCLA)
CAS:79-01-6
RTECS #:KX4550000
OSHA PEL:100 PPM
ACGIH TLV:50 PPM/100STEL, A5
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS

Ingred Name:NON-HAZARDOUS INGREDIENTS
Fraction by Wt: BALANCE
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:SUP DAT:PRODUCED SENSIT OF THE MYOCARDIUM TO EPINEPHRINE IN
    LAB ANIMALS & COULD HAVE SIMILAR EFT IN HUMANS. (ING 4)
RTECS #:9999999ZZ

Ingred Name:ING 3:ADRENOMIMETICS (EG, EPINEPHRINE) MAY BE
    CONTRAINDICATED EXCEPT FOR LIFE-SUSTAINING USES IN HUMANS ACUTELY/
    (ING 5)
RTECS #:9999999ZZ

Ingred Name:ING 4:CHRONICALLY EXPOSED TO CHLOROCARBONS .
RTECS #:9999999ZZ

Ingred Name:FIRST AID PROC:TAKE IMMED TO HOSPITAL/MD. IF UNCON/IN
    CONVLS, TAKE IMMED TO HOSPITAL. DO NOT ATTEMPT TO GIVE (ING 7)
RTECS #:9999999ZZ

Ingred Name:ING 6:ANYTHING BY MOUTH TO AN UNCON PERS. NOTES TO MD:NEVER
    ADMIN ADRENALINE FOLLOWING TRICHLOROETHYLENE OVEREXP.(ING 8)
RTECS #:9999999ZZ

Ingred Name:ING 7:INCREASED SENSITIVITY OF THE HEART TO ADRENALINE MAY
    BE CAUSED BY OVEREXPOSURE TO TRICHLOROETHYLENE.
RTECS #:9999999ZZ

Ingred Name:SPILL PROC:SWEEP INTO APPRVD CONTRS FOR DISP. DO NOT FLUSH
    TO SEWER. IF SPILLED INTO ENVIRONMENT, NOTIFY LOC & (ING 10)
RTECS #:9999999ZZ

Ingred Name:ING 9:STATE OFFICIALS IN ACCORDANCE WITH LOCAL, STATE AND
    FEDERAL REGULATIONS.
RTECS #:9999999ZZ

Ingred Name:WASTE DISP METH:I/A/W CLEAN AIR ACT, CLEAN WATER ACT, RCRA,
    AS WELL AS APPLIC FED, STATE & LOC REGS REGARDING DISPOSAL.
RTECS #:9999999ZZ

Ingred Name:OTHER PREC:SUPPLIES. HNDLG, STOR & USE PROC MUST BE
    CAREFULLY MONITORED TO AVOID SPILLS &/LEAKS. ANY SPILL/LEAK (ING
    13)
RTECS #:9999999ZZ

Ingred Name:ING 12:HAS POTENTIAL TO CAUSE UNDERGROUND WATER CONTAM
    WHICH MAY, IF SUFFICIENTLY SEV, RENDER A DRINKING WATER (ING 14)
RTECS #:9999999ZZ

Ingred Name:ING 13:SOURCE UNFIT FOR HUMAN CONSUMPTION. DO NOT USE
    CUTTING/WELDING TORCHES ON CONTRS USED TO STORE (ING 15)
RTECS #:9999999ZZ

Ingred Name:ING 14:VULCANIZING FLUID UNLESS EMPTIED & CLEANED. DO NOT
    BREATHE VAPS. USE ONLY W/ADEQ VENT. VENT MUST BE (ING 16)
RTECS #:9999999ZZ

Ingred Name:ING 15:SUFFICIENT TO LIM EMPLOYEE EXPOS TO
    TRICHLOROETHYLENE BELOW PERMISSIBLE LIMS. DO NOT EAT, DRINK/SMOKE
    IN (ING 17)
RTECS #:9999999ZZ

Ingred Name:ING 16:WORK AREA. NO SMKNG IN AREA OF USE. DO NOT USE IN
    GEN VICIN OF ARC WELDING, OPEN FLAMES/HOT SURFACES. (ING 18)
RTECS #:9999999ZZ

Ingred Name:ING 17:HEAT AND/OR UV RADIATION MAY CAUSE THE FORMATION OF
    HCL AND/OR PHOSGENE .
RTECS #:9999999ZZ

Ingred Name:RESP PROT:ROOMS, & OTHER CONFINED AREAS. RESPIRATORY
    PROTECTION PROGRAMS MUST BE IN ACCORDANCE WITH 29 CFR 1910.134.
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:LD50 (ORAL RAT): 4900-7000 MG/KG.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL: CONTAINS ING KNOWN AS CNS
    DEPRESS WHICH CAN CAUSE IRRIT OF RESP TRACT, DIZZ, NAUS, HDCH, LOSS
    OF COORD & EQUILIBRIUM, POSS CNS DMG, UNCON & DEATH IN
    CONFINED/POORLY VENTD AREAS. EYE:CAN R SLT IN DISCOMFORT, PAIN &
    IRRIT. SKIN:PRLNG/RPTD CONT W/LIQ CAN CAUSE IRRIT & DERM.
    INGEST:MAY RSLT (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:IN IRRIT OF MOUTH & GI TRACT ALONG
    W/OTHER EFTS AS LISTED FOR INHAL. VOMIT & SUBSEQUENT ASPIR INTO
    LUNGS MAY LEAD TO CHEM PNEUMONIA EDEMA WHICH IS A POTENTIALLY FATAL
    CNDTN. CHRONIC:PRLNG EXP OS ABOVE OSHA PERMISSIBLE LIMS MAY RSLTIN
    LIVER & KIDNEY DMG. TRICHLOROETHYLENE HAS BEEN EXTENSIVELY (SUP
    DAT)
Medical Cond Aggravated by Exposure:RESPIRATORY ILLNESS, LIVER AND
    KIDNEY DISEASES.

=======================  First Aid Measures  =======================

First Aid:INHAL:REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP, PREF
    MOUTH-TO-MOUTH. IF BRTHG IS DFCLT, GIVE OXYGEN. CALL MD.
    EYES/SKIN:FLUSH W/PLENTY OF WATER (SOAP & WATER FOR SKIN) FOR MIN
    OF 15 MIN, WHIL E REMOVING CONTAM CLTHG & SHOES. IF IRRIT OCCURS,
    CONSULT MD. THORO CLEAN CONTAM CLTHG & SHOES BEFORE REUSE/DISCARD.
    INGEST:IF CONSCIOUS, DRINK LGE QTYS OF WATER. DO NOT INDUCE VOMIT.
    (ING 6)

=====================  Fire Fighting Measures  =====================

Flash Point Method:TCC
Flash Point:NONE
Lower Limits:8%
Upper Limits:52%
Extinguishing Media:CARBON DIOXIDE, WATER FOG, AND/OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED PRESSURE DEMAND SCBA AND
    FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPS CONC IN CONFINED/POORLY VENTD AREA
    CAN BE IGNITED UPON CONT W/HIGH ENERGY SPK, FLAME/HIGH INTENSITY
    SOURCE OF HEAT. THIS CAN OCCUR IN CONCS (SUP DAT)

==================  Accidental Release Measures  ==================

Spill Release Procedures:LGE SPILL:IMMED EVACUATE AREA & PROVIDE MAX
    VENT. UNPROT PERS SHOULD BE EVACUATED. WEAR PPE. DIKE AREA TO
    CONTAIN SPILL. TAKE PREC AS NEC TO PVNT CONTAM OF GROUND & SURF
    WATERS. RECOVER SPILLED MATL O N ABSORB SUCH AS SAWDUST/VERMICULITE
    & (ING 9)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:HANDLE W/REASONABLE CARE. AVOID BRTHG
    VAPS. STORE IN COOL PLACE, USING CLSD CONTRS THAT ARE LABELED I/A/W
    STATE & FED REGS.
Other Precautions:CONC VAPS OF THIS PROD ARE HVR/AIR & WILL COLLECT IN
    LOW AREAS. DO NOT ENTER AREAS WHERE VAPS OF THIS PROD ARE SUSPECTED
    UNLESS SPECIAL NIOSH APPRVD BRTHG APPARATUS IS USED & AN OBSERVER
    IS PRESENT FO R ASSIST. AVOID CONTAM OF WATER (ING 12)

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF TLV IS EXCEEDED/IN EVENT OF SPILL, WEAR NIOSH
    APPRVD RESP EQUIP FOR ORG VAPS. USE NIOSH APPRVD SCBA/FULL
    FACEPIECE AIRLINE RESP W/AUXILIARY SCBA OPERATED IN PRESS DEMAND
    MODE FOR WORK PERFORMED IN	STOR VESSELS, POORLY VENTD (ING 19)
Ventilation:USE LOCAL EXHAUST OR DILUTION VENTILATION AS APPROPRIATE TO
    CONTROL EXPOSURES TO BELOW PERMISSIBLE LIMITS.
Protective Gloves:VITON OR SILVER SHIELD GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
    BOOTS, APRONS/CHEM SUITS SHOULD BE USED WHEN NEC TO PVNT SKIN
    CONTACT.
Work Hygienic Practices:PERSONAL PROTECTIVE CLOTHING & USE OF EQUIPMENT
    MUST BE IN ACCORDANCE WITH 29 CFR 1910.132 AND 29 CFR 1910.133.
Supplemental Safety and Health
EXPLO HAZ:RANGING BETWEEN 7.8%-52%. DECOMP/BURNING CAN PRDCE HYDROGEN
    CHLORIDE/TRACES OF PHOSGENE. EFTS OF OVEREXP:STUDIED FOR CHRONIC
    EFTS IN ANIMALS. WHILE THERE ARE STUDIES IN WHICH TUMORS WERE IND
    UCED IN MICE, THERE IS NO EVIDENCE THATTRICHLOROETHYLENE POSES
    CARCIN RISK TO HUMANS. CHLOROCARBON MATLS HAVE (ING 3)

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:198F,92C
Melt/Freeze Pt:M.P/F.P Text:-124F,-86C
Vapor Pres:57.8
Vapor Density:4.5
Spec Gravity:1.45 (H*2O=1)
Evaporation Rate & Reference:0.28 (ETHYL ETHER=1)
Solubility in Water:0.11%
Appearance and Odor:CLEAR, MOBILE LIQ W/MILDLY SWEET, ETHER-LIKE ODOR.
    IRRIT ODOR AT HIGH TEMPS.

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG ALKALIES (CAUSTIC SODA, POTASH), OXIDIZERS.
Stability Condition to Avoid:AVOID EXTREME HEAT, OPEN FLAME AND WELDING
    ARCS.
Hazardous Decomposition Products:HCL, PHOSGENE .

====================  Disposal Considerations  ====================

Waste Disposal Methods:CONTAM ABSORB, SOIL, WATER MUST BE DISP OF IN
    PERMITTED HAZ WASTE MANAGEMENT FACILITY. RECOVERED LIQ MAY BE
    REUSED, REPROCESSED/MUST BE TREATED IN PERMITTED HAZ WASTE
    MANAGEMENT FACILITY. IT IS YOUR D UTY TO DISP OF CHEM MATLS &/THEIR
    CONTRS (ING 11)

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.